A passenger front-wheel drive car VAZ Lada Granta is a variant of the budget car. Three types of transmissions are installed on the manufacturer's manufacturer: 5-speed, 4-speed and 5-step.
All specified transmissions require periodic replacement of working fluids, that is, you need to know which transmission oil is better for grants. Next, we will look at which gearboxes of Lada Grant is optimally used, and also to pay attention to when transmission oils are selected for Lada Granta.
Read in this article
Lada Granta: Transmission oil MCPP, automatic transmission and RCPP
Under the influence of temperature, mechanical and temporary factors, special additives contained in the working fluids gradually lose their properties and cease to meet the technical requirements provided for by the manufacturer.
As a result, the transmission is susceptible to increased wear and early failure. Lada Granta is designed to meet the characteristics of each box (technical, operational). The manufacturer recommends a certain type of working fluid, which meets the necessary standards and requirements for the operation of the transmission.
Working fluid poured into Grant Lada PPC:
- oils used for mechanical and robotic boxes - semi-synthetic oil LUKOIL TM 4 75W-90 GL-4 (depending on the climatic conditions in which the car will be operated, the viscosity class can change: 75W-80, 75W-85, 75W-90, 80W-85, 80W-90);
- oils used for automatic boxes - Genuine EJ-1 ATF.
If we consider the Lada Grant and transmission oil of the manual transmission, the mandatory replacement of the working fluids of the mechanical transmission of Lada Grant is not provided by the manufacturer, since transmission fluids are calculated for the entire service life of the car. But in reality it is not quite so. In order for the mechanical gearbox to serve for a long time, it is necessary to produce every 60,000 km.
The list of some oils used in the Lada Grant MCPP and the manufacturer recommended by the factory:
- mineral oil Kinetic from the Russian manufacturer Rosneft with viscosity classes: 80W-85 GL-4Lo 75W-90 GL-4/5;
- tM 4-12 transceux oil from the Russian Tatneft manufacturer with a viscosity class 75W-85 GL-4, developed on a synthetic and semi-synthetic basis with a multifunctional additive package;
- all-season Mineral oil TRANS KP from the Russian manufacturer "TNK" with a class of viscosity 80W-85 GL-4;
- all-season semi-synthetic oil TRANS KP Super from the Russian manufacturer "TNK" with a class of viscosity 75W-90 GL-4;
- synthetic oil Shell Spirax S5 ATE from the European manufacturer "Shell Transaxle Oil" with a viscosity class 75W-90 GL-4/5.
Note the working fluid level filled into the Lada Grant MCPP is 3.2 liters. At the same time, it is placed less at the time of replacement, as part of the oil does not succeed from hard-to-reach areas.
- If the oil is needed transmission grenade automatic transmission, recommendations for the selection and replacement periods are somewhat different from "mechanics". Lada Grant with automatic transmission is a novelty on the Russian market, since automatic transmissions were not so popular on the vases, or rather their massively was not installed at all.
In the case of the edge of the grant, the manufacturer went on the right path and did not develop a new automatic transmission for his car. Instead, the plant decided to take advantage of the already proven box JF414E from. As the reputation of Jatco on the world stage of transmissions manufacturers does not cause doubts, the management of the company "Auto VAZ" has decided to equip the Lada Grant Model automatic transmission JF414E.
According to the recommendations of the manufacturer's plant, the regulations for the replacement of transmission fluid into the automatic transmission car Lada grant is absent, since the liquid is filled with the entire service life of the car. In reality, the transmission fluid, undergoing constant temperature and mechanical loads, aging and loses its properties.
With amendments to the long-term practice of automatic transmission service, specialists recommend to carry out a maximum of 50 thousand km of run, and in cars with mileage to reduce this interval by 30 or even 50%.
The VAZ plant recommends that use in the automatic transmission of Jatco by car Lada Grant transmission fluid Genuine GM EJ-1 ATF or analog Nissan ATF Matic-S. By chemical composition of fluid compatible, they can be mixed. There are also other less expensive analogues of transmission oils, such as Aisin ATF AFW from the Japanese manufacturer.
The working level of the fluid, filled into Lada Lada Grant, which is recommended by the manufacturer, is 5.1 liters. However, in fact, it is impossible to pour less, as it is impossible to fully drain all the workout from the unit without disassembly.
- The oil transmission grenade RCPP is almost an analogue of lubrication for the manual transmission. In other words, with a robotic box installed on Lada Grant, everything is much easier than with a machine gun. The fact is that the principle of operation of a robotic box is very similar to the principle of operation of a mechanical gearbox, in which the oil is not subjected to excess overheating and pressure.
For this reason, the manufacturer has decided to use liquid in robotic transmissions used in the mechanical gearboxes of Lada Grant, discussed above. This was done to optimize the company's expenses for the production and maintenance of manufactured cars.
That in the end
Currently, the VAZ actively uses Renault - Nissan automotive corporation technology. Many nodes and aggregates installed on Lada cars have passed long-term verification in extreme conditions.
Accordingly, transmission fluids used in the production of automobiles concern are also specially designed to work in various units (mechanics, automatic or robot), both domestic development and production and foreign.
For this reason, only the original liquids and oils (motor and transmission) are optimally used. It is also allowed to transition to various analogues, but in this case you need to use such products that are high quality and fully meet all the tolerances of the manufacturer of the car.
Read also
Cable gearbox transfer by car Lada Granta (Lada Granta with a cable box): features and pluses of a cable checkpit on a grant.
Profile pipes are common in industrial and private construction. Of these, designed household buildings, garages, greenhouses, gazebos. The designs are both classically rectangular and vessels. Therefore, it is important to correctly make the calculation of the pipe to bend. This will preserve the form and provide structures strength, durability, on the site https://avtoindustriya.com/gruzovye-avtomobili/gruzovye-avtomobili-kitay/faw/.
Replacing oil in the gearbox Lada Grant Liftback, Datsun Mi-Do, On-Do (Lada Granta Chronicles)
The metal has its own resistance point, both maximum and minimal.
The maximum burden on the design leads to deformations, unnecessary bends and even breaks. When calculating pay attention to the type of pipe, section, dimensions, density, general characteristics. Thanks to this data, it is known how the material will behave under the influence of environmental factors.
Replacing the oil in a transmission transmission transmission on a grant
We take into account that at a pressure on the transverse part of the pipe, the voltage occurs even at points removed from the neutral axis. The area of \u200b\u200bthe most tangent voltage will be the one that is located near the neutral axis.
During flexion, the inner layers in bent angles are compressed, decrease in size, and the outer layers are stretched, extended, but the average layers are preserved and after the initial dimensions are completed.
A rifle that suits you, goes where you look. Thus, when you bring the guns to your face - you can press on the descent without hesitation, being confident, for whatever you watched - it will receive a shift in the center. In addition, with a gun that suits you is more convenient to handle it, and it is much more pleasant to shoot from it, on the site https://avtoindustriya.com/gruzovye-avtomobili/gruzovye-avtomobili-kitay/faw/.
How to find out if your rifle is suitable? Most people take a gun, throw it to the shoulder and tend to the sight. If the aiming line coincides with the expected: "It is not bad". The reverse side of the fit is the use of a trial gun with a fully adjustable lies. You shoot along the steel plate or on the plates, and the master at this time cares for the size of the bed.
Although a complete fit and a very useful thing - you can fit a gun under yourself on your own. More and more models of guns are semi-automatic browning, Benelli and Beretta, as well as pumping rifles and semi-automatic Mossberg - are sold with gaskets and spacers, with which you can change the bend (died), removal and the length of the butt. You will have to improvise with other guns.
Masters-gunsmiths use square steel plates measuring 91 or 121 cm, covered with paint or lubricant to see the fraction of a shot when checking the results of fitting the gun. If you do not have a plate, you can use a sheet or a plastic tablecloth. Suspend it and in the center aiming label with dimensions of 5 cm. Use the choc with a strong narrowing and stand up at a distance of 14 meters. First use an unfixed rifle and smoothly raise it to the cheek. Focus on targets and shoot immediately as soon as the gun touches the shoulder. Do not try to aim and do not look at the fly. Repeat until the hole appears in the target. If the hole is located strictly above or below the tag - you need to change the bend (died) butt. If strictly left or right - you need to change the removal. Each cm of displacement at a distance of 14 meters corresponds to 1, 58 millimeters of change of the size of the butt.
From 2013, almost all the front-wheel drive cars VAZ are equipped with a "cable" box. In grant sedans, she replaced less reliable node, denoted as "2190". In addition, the drive has become a cable, other changes appeared. The new box is called "VAZ-2181", and the volume of its crankcase was reduced from 3.3 to 2.3 liters. Here it is considered how to perform oil replacement in the gearbox Lada Grant with a cable drive.
Rare case: the box "2181" began to sweep on the run of 800 km. Confirmation is on video, and the problem was solved by replacing the oil.
Regulations on the replacement of oil in the checkpoint from AvtoVAZ
You need to change the oil in the PPC 2181 in one case - if the mileage exceeded 200,000 km. In theory, the entire service life of the car is indicated here, and the numbers are taken from the regulation.
It seems to be for the fill of the oil here everything is there
Still in the regulations are not said how often to check the oil level. Such checks are not needed, and therefore there is no diagnostic probe in the design of the crankcase. We will be important three details:
Drain plug (key "on 17"); Bulk cork and hole for level control; Reverse Switch.
Know that in the configuration "Standard" there is always a box "2190". The rule was performed for new cars released after 2013.
Which oil is flooded in the checkpoint from the plant?
From the plant oil in the gearbox Lada Grant may be as follows:
Tatneft transluux 75W85; ROSNEFT KINETIC SERVICE 75W85.
Each of the materials refers to the GL-4 class. Recall that it was about the box "2181", the volume of the crankcase of which is 2.3 liters.
The refueling volume can be 2.1 or 2.2 liters.
Preparation for replacement
First you need to warm the box. The car is then placed on the pit, stop it and try to turn out one plug. We are talking about the control plug (key "at 17").
Carter Protection View
If nothing happens with the plug, it will have to change the oil without control. It is not good. Try unscrew the switch located on the crankcase from above.
Oil volume in gearbox Lada Grant is known to everyone - it is 2.3 liters. But the replacement is still better to perform with control. The fill is made either through the control hole or through the switch of the switch. Access to the latter closes the filter.
Filter Case Operation
First disable the "minus" terminal (key "on 10"). Then a conventional crosst hole can be unscrewed the mounting screws.
The first two dismantling actions
Thin claw, which secures the expansion tank hose, also remove (see photo).
Turn off a pair of connections: DMRV and adsorber valve connector. The first one is oval (photo below). And the second is disconnected like this: tongue tongue, the terminal bar is removed.
Down with all Terminals!
The filter housing at the final step can be left to the side. You do not need to disconnect it with corrugation.
Rubber fasteners can be defeated like this: the rubber band holds the pliers, and the body is removed back (left, forward). Start with the right front support.
Intelligence fight
We are trying to remove the reverse switch. On the carter we are looking for a plastic connector (see photo) and immediately turn it off.
View of Carter CPP from under the hood
Round key "On 22" Try to unscrew the switch housing. Cancel replace, if you can not perform anything - neither pull out the "top" stopper, nor remove the switch.
When the switch is returned to the place, the threads are treated with a sealant. The tightening torque should be 28-45 N * m.
Detailed algorithm for replacing oil in the cable gearbox
Oil from gearbox Lada Grant is drained through the "bottom" cork. It is unscrewed by the key "on 17".
The simplest thing is to merge the oil
You need to unscrew the cork: do 1-2 turns with the key, then we substitute the container. And then unscrew the cork with your hand.
When the liquid is found, wipe the surface of the crankcase. We twist the cork back (the moment of forces is 29-46 N * m). Getting ready to refuel.
Hose and funnel are ready to work
Suppose the refueling goes through the switch of the switch. We put the hose in the hole, install the funnel. And begin to fill new oil.
Oil volume in Lada Grant CPP is 2.2 liters (maximum). So they say those who unscrew the control plug.
Access to the control plug closes the crankcase protection. If the plug was not unscrewed during preparation, measure exactly 2.2 liters. And if the control goes "according to the regulations", let the body be tilted to the right: to put a suitable cargo in the salon or trunk. The angle of inclination is 2-3 degrees (no longer needed).
At the final step, the Carter is cleaned from oil residues. All threaded elements are tightened by the recommended moments: a plug - 29-46 N * m, switch - 28-45 N * m.
Pour oil through the control hole
The photo shows how everything looks like, if you act according to the regulations. The lower tube is spinning, the top - on the contrary. And the refueling is carried out with the help of a syringe.
Oil in the gearbox Lada Grant comes through the hole "top" cork.
Instead of a syringe, you can use a hose with funnel.
There is no Carter Protection. She had to take off.
Which oil is better to fill in the regulations?
The staff leaders do not write, what oil to pour in the box with a cable-driven grants. The answer is in the instructions attached to another car, also equipped with a box "2181". We give a list:
G-Box Expert - 80W85, 75W90 Gazpromneft - 80W90, 80W85 TNC TRANS KP - 80W85 TNK TRANS KP Super - 75W90 LUKOIL TM-4 - 75W85, 75W80, 80W85, 75W90, 80W90 Rosneft Kinetic (Angarsk) - 80W85 Rosneft Kinetic (Novokuibyshevsk) - 80W85 (GL-4), 75W90 (GL-4 / GL-5) Tatneft Transluux TM-4-12 - 75W85 Shell: SPIRAX S5 ATE or TRANSAXLE OIL - 75W90 (GL-4 / GL-5)
If the quality class is not specified, the material complies with GL-4 standards.
The quality class "GL-5" has its own characteristics. With the material of this class, gears are preserved better, and not synchronizers.
Focus on temperature
Choosing an oil for the box, use the table:
Range "-12 - +50 gr. C » - 85W90. "-26 - +45" - 80W90. "-26 - +35" - 80W85 "-40 - +35" - 75W80 or 75W85 "-40 - +45" - 75W90.On the right is the class of viscosity.
Artikula
Below are the notation used by AvtoVAZ:
21230-1701326-00 - Turnkey plug "on 17" 21900-3710410-00 - reverse switch 21080-3512115-00 - Washer under the circuit breakerBy the way, the shops are determined by the puck as the pressure regulator plug gasket. Imported analogs will not be found.
List of typical errors
Heat the box, bleak gas in the floor and standing on neutral. The result - the engine is spooled. The oil is drained, and then it turns out that the filling hole cannot be opened. The puck laying is made of copper. Try not to lose it.All lubricating fluids in the Lada Grant car should differ in high quality, and the transmission oil is no exception. Lubrication must comply with general standards and approach a specific machine. Oils are characterized by technical characteristics and there are different brands, so the motorist should know how to choose a good oil for the gearbox Lada Grant, which will extend the service life of the box.
Factory grease
All transmission oil is classified according to what you have a gearbox - mechanical or automatic. Engineers of Lada Grant advise to pour into automatic transmission oil Genuine brand EJ-1 ATF, and it is recommended to fill LUKOIL TM4 to mechanical boxes. Depending on the region in which the car is operated, the viscosity class may be different. We recommend to explore grants into the engine.
In order to avoid unforeseen breakdowns and problems in the work of the gearbox, AvtoVAZ designers created a table at which you can pick up a transmission oil into a car brand Lada Grant. Before traveling to the store and buying the first lubricant, we recommend to explore this table below.
The mechanical transmission of grants includes 3-3.5 liters of oil, and the level is checked by a dipstick. It takes it every 75 thousand kilometers of run or once every five years. The procedure is performed in a convenient place, even at home, so there is no need to go to the service station.
About additives for oil
Never use an additive for oil for gearbox Lada Grant and do not pour other tools to improve the work of the node. To operate the vehicles of domestic production, it is recommended to use highly efficient modern transmission oils that do not need additional use of additives. In some cases, they even lead to damage to the gearbox by creating the opposite effect.
How many oil in the box is grants?
Checking the oil level in the Lada Grant CPP is recommended regularly - every 2-3 months. The car's manual transmission includes 3.1-3.5 liters of oil, and if fluids are much smaller, it is negatively affected by the operational service life of the transmission.
When to change in automatic transmission?
How often to change the oil in a manual box we talked above - just do it every 75 thousand mileage kilometers. As for the automatic transmission, it is recommended to change the lubricant every 15 thousand mileage kilometers.
What oils poured the owners of Grant?
Many car owners note a noticeable decrease in the volume of the transmission box when using the following grades:
- Shell Spirax S5 ATE 75W-90
- Motul G300 75W-90
- CASTROL SYNTRAX UNIVERSAL PLUS 75W-90
Lada Grant is a budget vehicle that is produced by the Volga automotive factory. Problems with the functioning of Lada Grant may arise as a result of neglecting the rules of vehicles of vehicles. The driver must take place in a timely manner. When passing inspection, there is often a need to replace the oil in the Lada Grant box. For the Lada, you should choose a fuel that will correspond to the brand of the automotive system.
Need to replace oil in the gearbox Lada Grant
Lada Grant can be equipped with both automatic and mechanical transmission. In the first case, a smaller amount of fuel for the gearbox is required.
Checking the PPC is relevant if the enlarged course of the lever is noted or the specific transmission is poorly activated. Manifestations may indicate that oil in the checkpoint lost its properties.
When is the replacement of oil in the gearbox of Lada Grant? Replacing the gearbox oil of Lada Granta can be performed independently or contact the service center.
On a number of car generations with a cable drive, there is a box of VAZ 2181, where the volume of the crankcase is 2.3 liters. It is recommended to add new trasmice in the PPC-2181 if the mileage exceeded 70,000 km. This parameter can be reduced if the vehicle was operated in difficult conditions. It should be found out how to fill in the box?
Application of transmission oil
In different trim, the Lada grants meet various types of high-speed boxes. What oil for gearbox Lada Grant should be used? Transmission oils for Lada Grant are widely represented in the domestic market. For this vehicle, it is better to fill such oil options such as Tatneft Transluux, Rosneft Kinetic Service with a viscosity of 75W-85 (class GL-4). How many oil in the box? Considering the fact that the transmission of the CAT is 2.3 liters, an approximately similar amount is required for this system.
Tatneft Transluux Rosneft Kinetic Service
How to check the oil level? In the GRANT PPC, the oil level can be accurately determined using such an item as probe. The oil level in the gearbox should not exceed the MAX label.
Oil replacement procedure
Stages of oil replacement in a box in Lada Grant (Liftbek):
- The car warms up to ensure optimum fluidity.
- Lada is started at the observation pit.
- It is necessary to remove the protection from the crankcase to access the drain hole.
- The plug is unscrewed, fuel is merged into a predetermined container.
- A checkpoint is unscrewed using a special key.
- Add oil in the checkpoint through the control hole. You should disable the battery terminal.
- To open access to the switch, you should dismantle the filter.
- Fill the transmission fluid should be through a special funnel, which should be complemented by a special hose.
The volume of fuel that needs to be pouring directly depends on the existing type of gearbox. It is better to carry out this procedure in gloves, as you can burn the transmission fluid.
When to change the oil in the box? It is worth contacting the station, if suspicious noise arose when driving. When the transmission overheating is evidenced by the appearance of the smell of Gary.
If the maintenance of the Lada is performed correctly, oil changes in a timely manner, the need to repair will not be required after a long time.
Thus, the quality of the fuel fuel in the box directly affects the automotive system resource. Check the oil level in the box The driver can be a dipstick that is pulled out of the PPC hole. In the MCPP Lada Granta should be poured about 2.3 liters of fuel. Replacing the fluid in the gearbox begins with the removal of the old lubricant. If the fusion oil changed the color or acquired an unpleasant smell, it is advisable to wash the gearbox. Difficulty Replacement Process does not cause.
The correct and durable work of the CAT directly depends on the control of the amount and quality of the oil used. Over time, the transmission fluid loses its properties. This is reflected in physical processes occurring inside the transmission unit. Replacing the oil in the Lada Grant box must be carried out in a timely manner. This procedure is easy to accomplish with your own hands.
How often does the topping and replacement of oil
Checking the level of transmission fluid is necessary every 15,000 km at the MCPP and every 5000 km during the automatic transmission, as well as when the flows are detected on the box crankcase. With an insufficient oil level requires a topping. At the beginning of the operation of the car, the consumption of transmission fluid is slightly increased. It should be regularly checked its level in the engine crankcase. The flow rate also depends on the style of driving and load on the motor.
Replacing the oil into the automatic transmission of Lada Grant, according to the car operating manual, is carried out in 70-75 thousand km or after 5 years from the beginning of operation. At the factory in the automatic transmission, oil is poured with good performance, which can guarantee uninterrupted operation throughout the entire service life of the vehicle. Consequently, the replacement of the transmission fluid in the automatic box is made only during the repair work of the aggregate.
Oil in MCPP car Lada Granta must be changed much more often. The first replacement of fluid in a manual transmission is required after 2-3 thousand km, then every 10-15 thousand km or once a year.
Selection of transmission fluid for grants
Oil quality is one of the important indicators. When buying should be made in the reliability of the supplier, so as not to purchase a fake. Semi-synthetic and synthetic fluids have proven well. The instructions for the auto indicate which substances should be used.
- LUKOIL TM 4;
- Novil Trans KP;
- Rosneft 60
- Tatneft transluux TM4-12;
- Shell.
For the "automat" at the factory, such marks of transmission substances are used: Genuine EJ-1 ATF, Nissan ATF Matic-S, semi-synthetic from LUKOIL.
Algorithm Level Check and Pulling Oil
Before checking the level of fluid in the gearbox grants, it is necessary to make sure that the vehicle is on the horizontal surface, and the oil is cooled. Check is carried out with a non-working engine. The transmission fluid indicator (probe) is removed from the hole in the gearbox crankcase.
Then it is wiping with a dry clean cloth, inserted into the crankcase until it stops and recovered again. The level of fluid should be between the minimum marks and the maximum on the pointer. In case of insufficient level, the substance should be addressed necessarily the same brand. To do this, you can use hose and funnel. Pulling the transmission fluid is carried out through the neck closed by the oil level pointer.
After 3-5 minutes after taking the transmission fluid, it should check its level again to ensure that it is sufficient.
Oil replacement algorithm in different types of Lada Grant
The process of replacing the transmission fluid in the mechanical and automatic gearbox grants is somewhat different. In 2013, AvtoVAZ modernized MCPP. A cable drive came to shift the transmission shift. This circumstance not only allowed to make the speed switching more clear, but also reflected on the filling volume of the box. Before starting work on the replacement of oil, it is necessary to clarify its required amount in the car operating manual.
Replacing the transmission fluid in the manual transmission
For the procedure, the following tools and materials will be required:
- fresh oil canine;
- key on 17;
- screwdriver;
- funnel;
- hose;
- capacity for working out;
- clean dry fabric;
- gloves.
Change the transmission fluid can even be happy. To begin with, you should drive the car to the observation pit, pre-warmed the gearbox. The optimal option is to carry out this procedure after a long trip. In the absence of observation pit or overpass, you can raise the right side of the car by jack. To securely fix the car, you should take care of the presence of stops under the wheels.
Next you need to find a drain hole. With the protection of the crankcase, a special hole is made. Solid defense is simply removed. A drain hole with a metal brush should be cleaned, then wipe with a clean cloth. The drain hole tube is unscrewed by the key to 17. The work is performed in gloves: emerging, the hot substance can burn hands.
The process of draining testing takes about 15-20 minutes. At this time, access to the filler plug should be provided: disable the battery terminal, unscrew the fastening screws of the air filter housing, turn off the air flow sensor terminal and other hoses and wires that impede the dismantling of the case, take the air filter housing to the side. When the exhaust oil is finally glass, the drain hole is closed by a plug.
Removes the level of transmission fluid. In the bay hole in which the dipstick was located, a funnel with a hose or a special syringe is inserted.
Next, it is necessary to pour a new transmission fluid. If the replacement process is performed for the first time, it is better to fill a little less than the recommended volume. Given the car strictly horizontal position, the oil level should be measured. If it is insufficient - to add, if excessive is to drain the surplus through the control opening. Things and drops on the box must be wiped with a clean cloth. Next, the air filter is installed.
After the fill, you should travel, switching the transmission steps consistently, then measure the fluid level again and adjust it if necessary.
