Check the oil into Hyundai H-1 automatic transmission (Starex) is every 5-10 thousand km. Such a prophylactic measure is recommended by the manufacturer in the car operating manual.
Mandatory replacement of the working fluid should be carried out at least 40 thousand km or 24 months. This period is indicated for the size of operation. It does not apply to the use of a car on a dusty road surface or in frequent plugs. In this case, completely change the oil to a new one is 20 thousand km. After all, the frequency of replacement of the ATF liquid depends not only on the run, but also on the nature of the ride.
How to properly check the oil in the ACPP HYUNDAI H-1?
Before proceeding with checks, it should be achieved that the working fluid reaches a temperature of 70-80 degrees Celsius. For this, quite a little ride on the car, and then install it on the site and do not forget to use the parking brake.
The next action will move the selector to all possible positions. Staying in each of them within 2-3 seconds, you can create a workload sufficient for subsequent check. The last position should be neutral.
Assess the number of working fluid will allow the corresponding probe. Taking it out, you need to clean, and then omit again into the nozzle. The next extraction will be shown the accurate result.
Turning oil into Hyundai Starex automatic transmission (H-1) is only if the level is below the range indicated by the word "HOT". The reduced level of transmission fluid is the main reason for the failure of friction. At low pressure, friction linings are poorly pressed against steel disks and to each other. As a result, they are very hot and the polluting oil is destroyed.
In addition to quantity, quality should be checked. The grown smell, the inconspicuous color or a change in the viscosity of the working fluid - all this signals for its replacement. In a serviceable gearbox with mileage, no more than 200 thousand alberts should be a dark red color without smelling Gary, if the liquid has become a brown-brown or black - it is better not to postpone and as soon as possible to make its full replacement.
How to replace the oil in the automatic transmission of Hyundai Zareks?
If another check showed the need to replace the working fluid, you should familiarize yourself with the detailed algorithm and manufacturer's recommendations before you start work. You will find this instruction further:
Unfortunately, nothing is said in the instructions from the manual that it is necessary to not only remove the pallet in order to clean the magnets from chips and merge the old oil more, but also clean or replace the filter with a mesh, delaying large particles. Therefore, we propose to read a more complete description of the partial replacement of ATP in the automatic transmission on the first-generation marks:
- Unscrew the bolt in the pallet key to "17";
- Unscrew all the mounting bolts of the pallet around the perimeter (the head to "10" and the cardanchik will be needed for several bolts);
- Unscrew and rinse either changing the filter;
- In order to merge more fluid, it is recommended to open the hydroblock bolts;
- We clean the magnets from the pod and rinse the pallet;
- Screw and install everything into place;
- When screwing the pallet pan and screw the drain bolt, it is desirable to change the gaskets.
- The oil is filled either through the dipstick, or through the technological bay hole.
Briefly such a procedure will look about as shown in the slides:
And in video to see and hear some important points:
How the ATF liquid changes on Hyundai Grand Starex in the garage conditions (if there is probe)
How to change automatic transmission oil on Hyundai Grand Starex (without probe)
It should also be noted that in the maintenance manual, filling volumes are indicated with a complete replacement of oil, with partial or when it produced with a violation of the exact technology, the amount of how much you need to pour into the automatic transmission of Hyundai Starex will be different, because it directly depends on the replacement method, it may be How 7, 10 or 11 l. So all 12 liters.
Differences in the replacement of liquid automatic transmission for Hyundai Starex to 2007 and Hyundai Grand Starex since 2009
We will not go deep into the details, but we will immediately move to the point. On the ages of two generations, there are several differences on the method of replacing the oil in the automatic transmission, its volume and actually the specification of the fluid flexible into the box. The first thing is worth noting is the transmission fluid, in the H-1 of the second generation, not ATF SP-II is required (the same is poured into the dispensing box), and ATF Matic-J Red-1 (original code. 0450000140). The second feature is the litter which will be needed for replacement. As it was noted earlier, it will depend on a lot of drain and replacement method, but in general, still in the automatic car of the car Hyundai H-1 it will be required more, at least 10 liters (in Hyundai H1 with a 2.4 G4KC and G4KE engine - 8.3 l, For 2.5 l D4CB - 10 l, and 4D56 - 8.3 l). The third difference is the bay method, on the boxes according to modern, the liquid is filled not through the probe, but a special bay hole (on the right side of the automatic transmission in the front). And finally, the fourth difference is the periodicity of the replacement, it is extended and is at least 100 thousand km.
From the tools, except for those that are needed to unscrewing the pallet and the filter will also be needed: hexagon on "8" (unscrew the plug-in tube), horn to 24 (level tube), oil refining syringe. Instead of the expensive original semi-synthetic oil Hyundai ATF Matistics-J, pour Ravenol ATF Red-1 synthetics (4014835719019 - 1 l., And 4014835719095 - 4 liter canister).
When moving from one type of oil to another, for example, from factory Apollooil or Matistics-J to Ravenol, a complete oil change must be performed.
Independent replacement of the transmission fluid automatic transmission of the Grand car gear 2.5 l D4CB strokes in general, it looks like this:
- Warm the engine and box;
- Drain from the pallet (somewhat about 4 l.);
- Remove the hose from the supply of cooled oil into the box (of two tubes from the automatic transmission to the cooling radiator together compounds with hoses throw off the one that goes from the top of the radiator) and drain about the 3rd. The procedure is performed on a launched motor with a selector translating for all modes;
- We pour so much oil so much to merge;
- On a warm engine, after the selector box was rewaked in all modes, we make a level control measure (setting into parking mode). On cars with the dipstick, in the usual way, and on those machines where the dipstick is missing, we are looking for a control hole (left in the course of automatic transmission).
Replacing oil in automatic transmission - mandatory procedure for long-term operation of the vehicle. Automatic transmission works correctly only with good transmission oil. Such liquid has various functions on internal elements.
What is oil in automatic transmission?
Liquid in the transmission plays an important role, preventing internal parts from accelerated wear. The oil in the automatic transmission serves to create an oil film at the point of contact between the driving items.
Main functions:
- Cooling. The liquid takes heat at the point of contact, which provides reduced wear of the internal elements;
- Anticorrosion properties. Details do not have time to rust due to the oil filth coated;
- Clutch. Increases the adhesion between the details and ensures the smoothness of the stroke;
- Friction. Due to the correctly selected viscosity of oil, friction between the parts decreases, even in the negative ambient temperature.
The car with bad oil behaves as follows:
- It is difficult to switch (there is a delay);
- There are shocks when switching;
- Noise appears in the box and the vehicle cannot move.
Why can oil flow?
To determine exactly the cause of the leakage will not work immediately. It will be necessary to conduct a thorough analysis. It is necessary to open the hood, and then get to the bottom of the car. To get to the bottom of the vehicle, you will need an observation pit or a lift. The following are only approximate causes of oil leakage from the transmission system.
Causes of oil leakage from ACPP Hyundai Grand Starex:
- Depreciation;
- Wear of the surface of the shafts, which are in contact with other sealing elements;
- The backlash of the primary shaft of the gearbox;
- Damage to the layer between the housings;
- Wear of the sealing element;
- The measurement probe level of the oil level is incorrect;
- The drain plug or the reverse sensor is poorly tightened.
The main cause of leakage - Wear salts. To understand how to eliminate leakage, you need to figure out, in what places there are similar kinds of elements.
They are installed in three places:
- On the semi-axes.
- Primary shaft.
- Gear selection stock.
To change the glands on the drive shaft, you will need:
When installing new seals, the following points are taken into account:
- Drive shaft cuffs for the left and right side are different. They differ in the direction of the car grooves. The cuff for the right side has an arrow that indicates the installation clockwise. On the left - on the contrary.
- Before installing the glands, the working surface will be necessary to lubricate with fresh oil.
- Cuffs are installed with light hammer blows using certain stands.
If the oil in the gearbox flows as a result of the wear of the gear selection string, it will be necessary to replace the gland:
- Unscrew the transmission drive hinge bolt and move away from the rod.
- Remove the protective hinge cover.
- Remove the gland. To do this use a screwdriver.
- Put a new cuff back. Used mandrel. Before installing the working surface, lubricate fresh oil.
Eliminate the sealing element on the drive shaft can only with the disassembled transmission. Such a procedure is combined with a clutch replacement. If you remove the exhaust bearing sleeve, you need to open access to the gland.
If the oil fluid flows from the junction of the transmission enclosures, it is better to dismantle and disassemble it. Carther jokes are carefully cleaned from the sealing layer and degrease. Before assembly, you must apply fresh oil to threaded connections.
The process of replacing oil in automatic transmission on Hyundai
Before starting the replacement of oil due to the unsuitability of the fluid to further use or due to the automatic transmission, it is necessary to collect instruments and materials for further work.
Required tools and materials:
- A set of hex keys (can and wrench);
- Screwdriver and pliers;
- Metal brush;
- Packaging for waste liquid;
- Fresh oil;
- Washer sealing on a drain plug.
Step-by-step oil replacement instructions in Handai Grand Starex:
- Heat the engine. It is advisable to travel by 5-10 kilometers.
- Merge oil. To do this, unscrew the crankcase protection. Cash to the drain traffic jam. Use the metal brush to clean the plug plug.
- Substitute the container under the drain hole. Carefully unscrew. Wait until the exhaust oil fluid is completely solved. Approximately 15-20 minutes.
- Unscrew the pallet. Rinse it from metal chips and dirt. Wipe dry.
- Install back.
- Pour oil using syringe. Pour in the required quantity by level.
- Perform a test trip by 10-15 kilometers using a switch lever in different positions. Return to a hole. Check the level. If necessary, add.
The process of replacing the oil in the automatic transmission to the Grand Starex is completed.
Oil selection for Hyundai Grand Starex
Replacing the oil in the automatic transmission to the Grand Starex is carried out using the original fluid. In four and five steps, it is recommended to pour the following types of oils:
- Dia ATF SP III;
- Hyundai ATF SP III;
- Chevron ATF SP III.
Oil volume in automatic transmission - 10 liters. Replacement frequency - every 60,000 km run.
Hyundai Starex - Korean minibus, one of the closest competitors Volkswagen Transporter. The car uses stable demand on the supported market, and finds a lot of fans - largely due to the possibility of repairing its forces. One of the most sought-after procedures is to check and replace the oil in an automatic transmission. According to official data, it is necessary to pour fluid every 10 thousand kilometers, given the difficult climatic and road conditions in Russia. Consider in detail how to correctly replace the oil in the Hyundai Starex automatic transmission.
What to do to replace
- It is good to warm the engine so that its temperature amounted to 80 degrees. To do this, it is enough to make a short trip around the city, observing frequent stops and regulation
- The car is installed on the viewing platform, the parking brake is turned on. Move the ACAP selector to several positions. It is advisable to stay on each mode for 3-4 seconds to create a load on the box. Then translate the selector to the "Neutral" position (N)
- Using the measuring probe, estimate the level of the remaining fluid. To do this, first get the dipstick, clean it, then re-lay in the hole. Finally, we will reach again and look at the exact level of fluid. The optimal volume is considered when the oil imprint is on the marks between MIN and MAX on a measuring probe.
- Naturally, it is advisable to check not only the level, but also the quality of the remaining lubricant. If the liquid does not have a specific burner odor, and also has light brown or light color, in this case you can only add new oil. If the oil of black and stinks the burner, then you will need a complete replacement of the fluid, together with the drain of the old lubricant
- The list of the following procedures is presented for those who need a complete oil change. So, the car is drunk on the overpass, the engine muffled. In place under the bottom of the car there is a plug plug-hole, it needs to be unscrewed, then observe the process of draining the waste fluid in a predetermined container
- It is necessary to dismantle the pallet with the head on 10
- After removing the pallet, access to the oil filter will appear, also remove it and change it to a new item.
- Rinse the pallet from mud sediments and metal chips, then fasten and install back to place, not forgetting to put a new oil filter
- Most likely, before installing back to the place of the pallet and drain plug, you will have to change their sealing gaskets.
- The next step is the bay of the new oil through the hole of the measured probe
- To avoid integrated car wash in the road dealership, you can make a double oil change. In this case, in the continuation of paragraph 10, you need to start the engine, and give it to work for a few minutes. At this point, it is necessary to turn on all transmissions with a delay of 2-3 seconds in each mode. This will allow oil faster to spread over all CACs
- Drown out motor and drain oil into the container
- Pour fluid through the control hole again. Bring the fluid level to a certain norm specified as MIN / MAX on the dipstick
- Run the engine, make a short trip, then measure the level again. If it is normal, then the process of replacing the oil in the Hyundai Starex automatic transmission is successfully completed.
How much to pour oils
In the instruction manual indicates the unequal volumes of the oil-filled oil into the Hyundai Starex gearbox. It all depends on the model year of production and operating conditions. Typically, the volume is within 7-12 liters.
What oil to fill in Hyundai Starex
There are several variants of transmission oils suitable for this model. Among them highlight the best products - it hyundai ATF Matic-J semi-synthetic-j, as well as cheaper Ravenol ATF RED-1 (synthetics).
On the benefits of replacing mineral oil in the manual transmission
It should be noticed that synthetic oil is often necessary to create a slippery layer of mineral oil in those parts of the manual transformed, where frequent contact is formed in engaging parts with high friction levels. The presence of even a slightly small number of low gears, in which there is no protective layer of synthetic oil, is able to cause the appearance of essential mechanical incidents, so the oil change in the MCPP Hyundai H-1 (Grand Starex) is a desirable and regular operation that cannot be forgotten. It should be noticed that maintenance on the car service, which is located on Warsaw that in the area of \u200b\u200bthe metro station South, is a good prospect of competently and cheaply serve your car.
Each driver is looking for an answer to the question - how often it is obliged to replace the motor oil in the automatic box. Naturally, the regulation was developed for any car - ten thousand kilometers, and the majority of motorists followed. But mostly, this number depends on the working conditions, and, of course, from the quality of the engine oil, nevertheless, the oil change in the automatic box is a fairly significant car care procedure, it is always necessary to remember. If you are intuitively worried about the performance of your beauty, then the problem is where to replace the oil in an automatic transmission switch in Moscow may be urgent.
When should be replaced with oil in the gential gender gender grand starex, m. Prague, s south
Educated installers constantly say that the engine oil should be replaced regularly. At the same time * complete oil change in the gearbox apparatus the price may decrease a little. It is necessary to emphasize the moments in which the oil change in the box can be somewhat faster:
- repeating trips for short distances - the motor can not warm up for such a short time, which is why condensate appears with all the resulting. In hard frosts - it is very relevant, remember that the oil change in the checkpoint will allow you to disappoint in your car;
- permanent trips at the pace of automotive congestion - at this time the operation of the cooling system deteriorates significantly, oil is warmly heated, and, therefore, strengthened loses its quality. It is necessary to recall that the hardware replacement of oil in the automatic transmission will increase the service life of the entire engine.
The cost of replacing the oil in the PPC Hyundai H-1 (Grand Starex)
It is necessary to emphasize that during the daily operation of the car, the motor oil loses all its good qualities over time, and at that moment the variator oil replaced becomes really necessary for your car. This is expressed by the fact that the engine oil is contaminated by harmful waste of products combustion of diesel fuel. Replacing the oil in the manual transmission - will provide an opportunity to stretch the service life of the manual transmission, - come to a hundred at the Prague metro stop, and you guarantee the perfect quality and perfect service.
What else should be aware of the replacement of oil in the manual transmission and automatic transmission of Hyundai Grand Starex
It is necessary to take into account the pace, the conditions of movement and the proportionality of movement in the village or by the autobahn - all this affects the frequency of this procedure, as is the drop of the oil of the variator. The greatest and minimum temperatures (in the cold and warm time), moving on country roads, towing heavy cargo is much reduced by the change interval of each synthetic oil.
Our advice is the change of oil and filters every 50,000 km, and it is worth remembering - regular oil change in the gearbox will be a key condition for its long-lasting and trouble-free operation.
Hyundai Starex automatic gearbox needs a periodic replacement of oil, although many motorists mistakenly believe that oil does not require replacement in automatic transmission.
When and why you need to change the oil?
Replacing the oil in the ACPA Strex is the necessary procedure to maintain transmission in working condition. Special fluid lubricates working elements, knots and mechanisms of the box, preventing rapid wear. If you do not know when changing the oil in the Hyundai Starex box - refer to the specialists.
Do not everyone know how much oil pour into Starex automatic transmission. The volume of fluid flexible depends on the specific model of the box. It ranges from 4 to 8 liters, only auto-service specialists can say the exact figure.
If the oil is not replaced in a timely manner, then it may be necessary to repair ACPS Starex. The cost of such a repair is often high enough, so it is better not to experience fate, and regularly replace the fluid.
The REKPP car service specializes in replacing oil in a box of Hyundai Starex. It will cope with this procedure on its own without experience quite difficult, and our experts will do everything in its best. Replacing oil in automatic transmission - prices are quite affordable to carry out this procedure every 50,000 km or more often.
