How to add oil to automatic transmission Citroen C5. How to change the oil in the automatic transmission citroen c5

Changing the oil in the Citroen C5 gearbox is most often associated with the repair of the automatic transmission itself, or it is replaced with a new one during work to eliminate oil leaks, since it must be drained for work. The oil in the automatic transmission is poured by the manufacturer once for the entire service life of the car. It is recommended to entrust the oil change in the automatic transmission Citroen C5 to professionals, but in some cases this operation can be done on your own.

Functions aTF oils in automatic transmission Citroen C5:

  • effective lubrication of rubbing surfaces and mechanisms;
  • reduction of the mechanical load on the units;
  • heat removal;
  • removal of microparticles resulting from corrosion or wear of parts.
The color of ATF oil for automatic transmission Citroen C5 allows not only to distinguish oils by type, but helps to find out in case of a leak, from which system the fluid escaped. For example, oil in automatic transmission and power steering has a red tint, antifreeze is green, and in the engine it is yellowish.
Reasons for oil leakage from automatic transmission in Citroen C5:
  • wear of automatic transmission oil seals;
  • wear of the surfaces of the shafts, the occurrence of a gap between the shaft and the sealing element;
  • wear sealing element Automatic transmission and speedometer drive shaft;
  • backlash input shaft Automatic transmission;
  • damage to the sealing layer in the joints between automatic transmission parts: pallet, automatic transmission housing, crankcase, clutch housing;
  • loosening of the bolts that ensure the connection of the above parts of the automatic transmission;
Low oil level in automatic transmission Citroen C5 is the main reason for failure of clutches. Due to the low pressure of the fluid, the clutches do not press well against the steel discs and do not contact each other tightly enough. As a result, the friction linings in the Citroen C5 automatic transmission become very hot, carbonized and destroyed, significantly contaminating the oil.

Due to lack of oil or poor quality oil in automatic transmission Citroen C5:

  • plungers and channels of the valve body are clogged with mechanical particles, which leads to a shortage of oil in the bags and provokes wear of the sleeve, rubbing pump parts, etc.;
  • steel transmission discs overheat and quickly wear out;
  • rubberized pistons, thrust discs, clutch drum, etc; overheat and burn out;
  • the valve body wears out and becomes unusable.
Contaminated automatic transmission oil cannot fully remove heat and provide high-quality lubrication of parts, which leads to various malfunctions of the Citroen C5 automatic transmission. Heavily contaminated oil is an abrasive slurry that creates a sandblasting effect under high pressure. An intense impact on the valve body leads to a thinning of its walls at the locations of the control valves, as a result of which numerous leaks may occur.
You can check the oil level in the automatic transmission Citroen C5 using a dipstick. The oil dipstick has two pairs of marks - the upper pair Max and Min allows you to determine the level on hot oil, the bottom pair - on cold oil. Using the dipstick, it is easy to check the condition of the oil: you need to drip oil onto a clean white cloth.

When choosing a Citroen C5 automatic transmission oil for replacement, you should follow a simple principle: it is best to use an oil recommended by Citroen. Moreover, instead of mineral oil you can fill in semi-synthetic or synthetic, but in no case should you use oil "class lower" than prescribed.

Synthetic oil for automatic transmission Citroen C5 is called "irreplaceable", it is poured for the entire life of the car. This oil does not lose its properties under the influence of high temperature and is designed for a very long life of Citroen C5. But we must not forget about the appearance of mechanical suspension as a result of wear of the clutches with a very significant mileage. If the automatic transmission has been operated for some time in conditions of insufficient oil, it is required to check the degree of its contamination and, if necessary, replace it.

Methods for changing the oil in automatic transmission Citroen C5:

  • Partial oil change in the Citroen C5 box;
  • Complete oil change in the Citroen C5 box;
Partial oil change in automatic transmission Citroen C5 can be done independently. To do this, it is enough to unscrew the drain on the pallet, driving the car onto the overpass, and collect the oil in a container. Usually up to 25-40% of the volume flows out, the remaining 60-75% remain in the torque converter, that is, in fact, this is an update, not a replacement. To update the oil in the automatic transmission of Citroen C5 to the maximum in this way, 2-3 replacements are required.

A complete oil change of the Citroen C5 automatic transmission is carried out using an automatic transmission oil change unit, by specialists in the car service. In this case, more ATF will be required than the Citroen C5 automatic transmission can accommodate. One and a half or double volume of fresh ATF is used for flushing. The cost will be more expensive than partial replacement, and not every car service provides such a service.
Partial ATF oil change in automatic transmission Citroen C5 according to the simplified scheme:

  1. Unscrew the drain plug, drain the old ATF oil;
  2. We unscrew the automatic transmission pan, which, in addition to the bolts holding it, is processed along the contour with a sealant.
  3. We get access to the automatic transmission filter, it is advisable to change it with each oil change, or rinse it.
  4. At the bottom of the pallet there are magnets that are needed to collect metal dust and chips.
  5. We clean the magnets and rinse the pan, wipe dry.
  6. We install the automatic transmission filter in place.
  7. We install the automatic transmission pan in place, replacing the automatic transmission pan gasket if necessary.
  8. We tighten the drain plug, replacing the gasket drain plug for automatic transmission.
We fill the oil through the technological filler hole (where the automatic transmission dipstick is located), using the dipstick we control the oil level in the automatic transmission to a cold one. After changing the oil in the automatic transmission, it is important to check its level by driving 10-20 km, already with the automatic transmission warmed up. Top up if necessary. The regularity of oil changes depends not only on the mileage, but also on the nature of the ride on the Citroen C5. You should be guided not by the recommended mileage, but by the degree of contamination of the oil, systematically checking it.

How much does an oil change in a turnkey automatic transmission cost?

Number of gears Partial replacement Complete replacement
4 gears(DP0 AL4) RUB 5.900 9.000 RUB
6 gears (TF70 TF80) RUB 6.680 RUB 10.300
Variable speed drive (JF011) * RUB 10.400 * RUB 14,000 *

*Included in the price: work, transmission fluid, maintenance kit (filter, gasket)

* The cost may be higher / lower if the client chooses otherwise transmission oil of the proposed. We are an official distributor of: SHELL, Mobil, Motul, Castrol, Wolf, United Oil.

* In the JF011E variator, the filter cartridge is changed every 60,000 km, the filter in the pan is changed at the request of the client.

Transmission fluids we use

10% discount on oil change for all subscribers:

Consumables prices (Oil, filter)

Do I need to change the oil in the automatic transmission?

You've probably heard of the term "maintenance-free automatic transmission". Very often, this is guided by many services that do not know how / do not want to change the oil in the transmission. In fact, according to all international norms and rules, an automatic transmission oil (ATF) and filter change is required every 50,000-60,000 km. In this case, the car owner asks himself the question - "What replacement do I need? Partial or complete?"

Partial or complete oil change in automatic transmission?

Partial replacement (ATF renewal) is carried out without automatic transmission flushing. To carry out such work, an average of 4-5 liters and half an hour of time are required. The new oil is mixed with the old one, and the operation of the box becomes smoother. Many motorists believe that it is better to carry out an exclusively complete ATF replacement, flushing the system and displacing the old fluid. We do not pursue the goal of earning as much as possible on our clients, but warn about possible problems, and we recommend performing ONLY partial replacement in some cases.

For example, if the car's mileage is more than 100,000 km, and the oil in the box has never been changed, then such a replacement can negatively affect the operation of the automatic transmission, up to its complete failure. In cars with solid mileage, this is due to the fact that with a complete replacement transmission fluid with automatic transmission flushing, various deposits are washed out throughout the system, which clog oil channelsand without proper cooling, the box dies quickly enough. In this case, to maximize replacement of the old oil, 2-3 partial replacements at intervals of 200-300 km. This will certainly not be comparable to a complete ATF replacement, but the percentage of fresh fluid will be 70-75%.

In what cases is a complete ATF replacement carried out?

All of the above problems do not apply to car owners, who are every 50,000-60,000 km. carried out a routine oil change in the transmission. In this case complete replacement oil in automatic transmission allows the box to serve faithfully, and increases its resource by 150-200%.

Timely oil change in automatic transmission Citroen C5 can significantly extend the life of transmission parts and avoid an expensive unit. In addition, a new transmission fluid has a positive effect on driving comfort. vehicle: Gear changes are softer and more invisible.

When to change?

Changing the oil in the automatic transmission Citroen C5 is not provided for by the manufacturer - the liquid filled in the factory is designed for the entire service life of the gearbox. However, taking into account the Russian road and climatic features, maintenance is still worth carrying out: experts recommend doing this with a frequency of 60 thousand kilometers.

If there is no data on the last oil change, then the reason for performing the operation may be:

  • aTF color change (darkening);
  • the presence of a characteristic "burnt" smell;
  • detection of traces of metal dust in the oil;
  • failures in the transmission.

How to change?

The oil is changed in two ways:

  • partial replacement, which involves removing the automatic transmission oil pan and installing a new filter element (performed manually);
  • complete (hardware) replacement, requiring connection to a special stand.

The procedure for changing the oil in the automatic transmission Citroen C5 is associated with a number of difficulties due to design features car. That is why it is more logical to entrust it to professionals.



Similar articles