Block fuses and relays on Volkswagen Passat B3-B5 cars is an important node electronic system. In the event of any problem with the wiring and electronics of the machine, exactly this device is checked first.The burned fuse must be replaced and reveal the cause of its failure. How is a similar event on B3-B5 models, read below.
How the device works
In the electronic chain of almost every car device there is such a node as a fuse. It is necessary to protect the electrical system from possible closure. Excludes the use of fuses only in chains with too high power Current.
It is worth noting that the "Defenders" of electricity are collected in one place for the convenience of checking for a particular electrical appliance during repair. Each electrical system of a single device has the highest possible force flowing through it. The fuse is installed with a lowered threshold so that in case of failure of electrocups and exceeding the strength of the current, it burned, and not the wires. The feasible "Defender" de-energizes the entire chain, thereby preventing a short circuit and a potential fire.
The number of fuses in the block directly depends on the equipment of your trade wind by various electrical appliances, that is, from its configuration.
Location node
Depending on the Passat model, the number of blocks and their location may vary. Therefore, when repairing electrical equipment, it is worth considering this moment.
Vehicles B3-B4 rules are equipped with one main fuse block, which is located in the car. Also worth paying attention to that Depending on the configuration, a number of additional devices can be installed in your machine. In any case, the block is in the cabin and it is in it that the fuses are collected from almost all electrical products.
In order to get to this node in Passat B3-B4 you need to do the following actions:
- Find the lower area of \u200b\u200bthe console panel, located opposite the driver's seat.
- Remove the part of the plastic torpedo in this zone. In some cases, this will not be needed, since access to the block can be obtained by dismantling a special cover.
As for the Passat B-5, so here is a slightly different story. In it, German engineers mounted 2 blocks:
- the main - contains all elements of the electronic equipment of the car low power (headlights, stove, etc.), is there in the same place, where and the Passown B3-B4;
- additional - equipped exclusively relay and has a sufficiently small size, this device is located in the protective cover area under torpedo, opposite the passenger seat.
Regardless of what car from the Passat line is repaired electronics, replacing the fuses are necessary in compliance with some rules. First of all, make sure the full of electrocups, which burned the fuse. If it is faulty, it is necessary to repair it. Otherwise, the re-brave will happen. It is also worth considering the maximum current force threshold installed by the manufacturer, which passes through the fuse, for a separate electrical appliance. By installing a new "defender" with a greater throughput force, the risk of fire when the wiring is faulty increases at times.
Important! It is possible to replace the elements in the block only when the ignition is turned off and the muted motor.
Block diagram Passat B3-B5
Passat B2 Fuse Block:
Passat B2 fuse block:
In the above schemes, there are all data on the location of the fuses and their nominal current force threshold. Replacement must be carried out taking into account this information.
In general, repair the electronics in the Passat B3-B5 is quite simple, if you know some tricks and additional information. Conducting repair activities with a fuse block, it is important to comply with safety and make all the work extremely gently good luck on the roads!
Volkswagen Polo. - this is modern car From the German manufacturer, who likes many car owners. Beautiful body forms and comfortable salon attract lovers inexpensive cars. But even the reliable models of Germans meet certain nuances and malfunctions.
About everything, which is associated with electrics, electronic circuit protection and polo schemes comfort and Highline, you can read in this article. If suddenly some kind of equipment, such as fuses and relays Volkswagen Polo. It fails, the following fuses, relays and schemes are indicated in the lists, and in the comments you will find ways to solve common problems.
This article describes fuses and relays. Volkswagen Polo. In ComfortLine and Highline equipment. In the TRENDLINE configuration, the numbering and designation of some fuses may differ.
When determining the safety of the fuses, use the tester, this will eliminate errors, quickly ring the necessary chains or measure the voltage in the connectors. Always bring backup fuses and relays, because They can help you out at the time of an unexpected breakage or short circuit.
Salon block:
Fuses number 1-24:
1 - Reserve.
2 (10 a) - Steel Switches, Glass Fackers. If the washer does not work windshield, Check the fluid level in the bull of the washer, in the winter, check the liquid in the tubes of the system and nozzles. Serve power from the battery on the pump-pump, if it does not work replace the new one. If it works, check the wiring, connectors, terminals and the right-hand drive switch.
3 (5 A) - gas station, engine control system. If the fuel pump stopped swing gasoline and does not create right pressure at fuel system For engine operation, check in addition, the fuse 36, the SA3 power fuse and the R4, R8 relay. If the fuel pump is connected directly to the battery, it does not work or works with interruptions, replace the new one.
4 - reserve.
5 - reserve.
6 (5 A) - dashboard. If the arrows, sensors or display stopped working on-board computer on the dashboard, Check in addition, fuses 18, 20, 38. Check also the connector with wires on the back of the dashboard.
7 (5 A) - Gosnomer lighting lamps, headlighting angle corrector.
8 (10 a) - fuel injectors.
9 (5 A) - anti-lock brakes ABS. . If stopped working aBS system The same lamp tanned on the dashboard, check the power fuses 1, 4 and SA5 under the hood, as well as the sensors located at the wheel. Most likely, their wires pulled out, crumbled or loosely connected connector. After plotting with the front suspension when assembling nodes, you can forget to install sensor wires into special holders, because of this, they are usually shared. If some sensor is faulty, replace it with a new one.
10 (5 A) - Starter Relay Chain, Electrical Management, Speed \u200b\u200bSensor. If the starter does not work, check in addition, fuses 19, SA3 power fuse under the hood and R3 relay. If the car from the salon was bought recently, and in the frost ceased to turn the starter (clicks), most likely frozen oil in it, you need to warm up the car.
If the car is no longer new and the starter does not twist, check the battery charge, if necessary, charge it or install a new one. Check the contacts of the terminals on the battery, if they oxidized, clean their inner part and tighten firmly. Check the starter operation and the relay by closing the contacts on the retractor (when the transmission is turned off, on neutral).
If a speedometer stopped working or working with interruptions, most likely the case in the speed sensor and its contacts.
11 (5 A) mechanism of headlight angle corrector.
12 (5 A) - Electrically regulating side mirrors. If the mirrors stopped adjusted, check the wiring between the body and the front doors, and inside the mirrors themselves. To enable heated mirrors, turn the joystick adjusting the mirrors by 180 degrees.
13 (15 A) - automatic transmission.
14 (5 A) - Airbags. When starting the engine, the airbag lamp on the dashboard should light up for about 5 seconds and go out. If it continues to burn, then there is a malfunction or a saved accident error in memory. To set the exact reason, you need diagnostics.
15 (5 A) - Heating Glass Ferrous Injectors. Heating nozzles works when heating mirrors (rotation of a 180 degree joystick). If it does not work, check the connections and the condition of the wires under the hood at the connection site to the nozzles.
16 (5 a) - Parktronic.
17 (10 a) - E / M Valve Adsorber, Lambda Prondes.
18 (5 a) - rear fog light, dashboard.
19 (5 A) - Lamps of the front dimensional lights, audio system, electrical control unit, signal of the "Running engine" position key in the ignition lock.
20 (5 A) - Steal Switches, Dashboard. See before. 6.
21 (10 a) - light in the cabin and trunk. If the lighting is not working in any position, check the lamps in it, switch and wiring. If the light does not light up only when you open the doors, check the end switches in the doors, their connectors and wiring from them to the control unit.
22 (5 A) - climate control, key lock in the ignition lock. If when you turn on the stove and burn a hot temperature blowing cold airMost likely you have a low level of antifreeze in the tank or hit the air into the cooling system.
Check whether the air intakes, the fan and the radiator were not clogged, cleaned if necessary. It may be in dampers, check that they opened and closed correctly. If the heater motor does not spin at all, check its condition, feeding it to it 12 V.
23 (7.5 A) - control of electrical equipment, engine control system, selector of automatic transmission modes.
24 (5 A) - Heated Side Mirrors.
Fuses No. 25-60:
25 (5 A) - radiator fan, climatic installation, pressure meter. If the fan does not work, see the power fuse 2.
26 (7.5 A) - electric power steering. If the steering wheel began to spin tight or there were problems in the work of the amplifier, check it apart, except for this, SA4 power fuse. Do not leave a parked car with fully twisted wheels, and also do not keep the wheels twisted before the stop for more than 5 seconds to avoid breakdowns of EUR. EUR itself is located on the shaft in the steering column.
27-32 - Reserve.
33 (5 A) - Stop Signal Switch. If stop signals stop burning, then check the fuse 43, as well as the lamps, their connectors and the switch to the brake pedal, wiring.
34 (7.5 A) - far light In the right fare. If not working, check the lamp. If both headlights do not burn, check their lamps and a steam light switch.
35 (10 A) - engine control system, powder electrical equipment.
36 (15 A) - Beltzonasos. See before. 3.
37 (25 A) - heated front seats. If one of the front seats ceased to warm up, check the connector and wires under the seat. Check if the voltage on this connector comes. If the voltage is, most likely lost contact inside the seat or occurred the heating element. If there are no voltages, check the wiring and the power button.
38 (7.5 A) - Far Light in the left headlight, dashboard. See before. 34.
39 (10 A) - Middle Light in the right spotlight. If not working, check in addition, the SA3 relay, as well as lamps and contacts in headlights. If you still do not work, check the light switch on the dashboard to the left of the steering wheel, its contacts, and a subwoofer, wiring.
40 (30 A) - heater / climate control / air conditioning fan. See before. 22.
41 - Reserve.
42 (15 a) - cigarette lighter. Usually works only when the ignition is turned on. If stopped working after connecting the device, most likely a short circuit, use an additional outlet or splitter to connect instruments. If the fuse replaces does not help, check the connector itself, contacts in it, the connection connector and wiring.
43 (15 A) - turn signs, alarm, lamps of stop signals, electrical equipment on-board network . If turn signals do not work, check the lamps and contacts in the landing connector. If the turn signals began to flash faster or slower, check all the connectors for lamps for the absence of short circuit, as well as wiring. The case may be in the steering wheel switch of turns.
44 (15 A) - signaling siren, volume sensor.
45 (15 A) - Radio, Audio System.
46 (20 a) - beep. Usually works only when the ignition is turned on. In order to work always, you can reflash the control unit. If it does not work, check the function of the signal itself. Located on the driver's side, under the left headlash. To get to it, it is convenient to remove the left front wheel and unscrew the liner. Serve me, if it works, it means the case in the wiring or steering switch.
47 (20 A) - Front Wipers. If the "wipers" stopped working, check the steering switch and the gear motor. In winter, it could get into it and frozen water. Inspect the entire mechanism for blocks and ice. Check if the washer works. If the washer does not work, too, try to eliminate the washer malfunction, then cleaners. It may be in wiring / connectors.
48 (25 A) - Central Castle - Doors, Trunk Castles, Luke Gollard. If door locks are not closed, check the end switches of doors, one of them could fail or disappeared in the wires between the body and one of the doors. Check also the mechanisms of door locks and their drives, wiring.
49 (5 A) - Lantern rear stroke . The lamp is one, is on the right. If it does not work, check its serviceability and contacts in the connector. Also check the switch on the gearbox (on the automatic switch in the selector).
50 (25 A) - Electric windows in the driver's door. If the driver's glass is lowered and rises with interruptions, every time, most likely the case in overheating of the motor. A common problem known to dealers.
51 (25 A) - Electric windows in front passenger doors. If windows work incorrectly, try to program them. To do this, open and close each glass, continuing to hold the button in the extreme position 1-3 seconds.
52 (30 A) - Electric windows in rear doors . See before. 50 and 51.
53 (30 A) - heating elements rear glass . The rear window electrical heating in the polo is automatically turned off. If not working, check the terminals on heating elements, serviceability of the button and its contacts, as well as the wiring on the car body. You can get to the button by removing the magnetic frame.
54 (15 A) - fog lights.
55 (15 A) - ignition coils.
56 (30 a) - windshield electrical heating.
57 (5 A) - Front left and rear left lamps of dimensions, parking light on the left side.
58 (5 A) - Front right and rear right lamps of dimensions, parking light on the right side.
If dimensions do not work, check other than these, fuse 19 and R7 relay, lamps, light switch to the left of the steering wheel and wiring. Parking light turns on when the ignition is turned off, the shift of the steering wheel switch to one of the positions - or only the left dimensions will light up, or only the right. Function to refer to parking in the dark time.
59 (10 a) - Middle Light in the left headla. Similarly, before. 39.
60 - reserve.
Auto fuses:
Mounting block of power fuses:
Installation unit of power fuses is located in motor compartment, under the hood of the car, over the battery. To get to it, remove the plastic lid.
Fuses No. 1-6:
1 (25 A) - ABS brake anti-lock
2 (30 A) - radiator fan (cooling system). If it does not work, also check the adjacent fuses 3, SA6 and fuse 25 in the cabin block, make sure normal level cooling fluid, repair of the fan motor, temperature sensor and thermostat, fan sensor, as well as wiring and electronic block Control.
3 (5 A) - control of the radiator fan.
4 (10 a) - anti-blocking brakes ABS. See before. 9 in the salon block.
5 (5 A) - electrical equipment, onboard network.
6 - reserve.
Fuses No. SA1-SA7:
SA1 (150 a) - generator. If the generator does not work and the battery does not charge, check this fuse, the battery terminals, the generator belt and its tension. Adjust when weakened. If the belt was worn out or broke out, replace the new one. Check also the wires suitable for the generator and their contacts, if necessary, tighten the nuts.
It may be in the generator itself, its brushes and windings. You can repair the current or replace new, in the absence of experience, contact your electrician or official dealer.
SA2 - backup.
SA3 (110 a) - starter, outdoor lighting, subwoofer switch, fuel pump, headlights, headlights, front dimensions.
SA4 (50 A) - electric power steering.
SA5 (25 A) - ABS brake anti-lock. See before. 9 in the salon block.
SA6 (30 A) - radiator fan control.
SA7 - Reserve.
Car relay:
All car relays are bred in a separate mounting blockwhich is in the dashboard from the left driver's side.
R1 - backup place.
R2 - Windshield Heating Relay. See fuse 56.
R3 - Starter Lock Relay.
R4 - gasoline supply relay on pressure highway.
R5 - Power Relays.
R6 - backup place.
R7 - lamp relays of dimensions in front. See Fuses 57 and 58.
R8 - Pellezone Relay.
R9 - climatic installation relay.
R10 - contact relay "X".
R11-R15 - backup.
Access to fuses and relays opens after removing the shelves from the bottom of the front panel. In later models, access opens after the lid removes. The main fuses are located under the relay. The fuses are numbered, and on the shelf or on the lid there is a list of chains that these fuses protect. On some models there are additional fuses and relays that are located above the main.
Cars 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995, 1996, 1997, 1998
Where is the mounting block of the relay and fuses. The block is located at the bottom of the instrument panel from the driver.
Access to the block is possible after unscrewing clamps and removal of tray
The fuse block has a numbering.
To disconnect the wiring harness of the contact connector from the back of the fuse block and the relay, remove the locks by approximately 5 mm in the direction indicated by the arrow
Designation of fuses
Fuse number | Fuse color | Protected chain |
F1 (10 a) | Red | Middle Light (left headlight) |
F2 (10 a) | Red | Middle Light (right headlight) |
F3 (10 a) | Red | Lighting the combination of devices and license plate |
F4 (15 a) | Blue | Rear door glass cleaner, hatch, self-leveling rear suspension control unit |
F5 (15 A) | Blue | Cleaner windshield, wind and rear winder washer |
F6 (20 a) | Yellow | Heater Fan, Air Conditioning |
F7 (10A) | Red | Overall light (right) |
FB (10 a) | Red | Overall light (left) |
F9 (20 a) | Yellow | Rear window heating and rearview mirrors |
F10 (15 A) | Blue | Fog lights and rear fog lantern |
F11 (10 a) | Red | Far Light (left headlight), Far Light Inspection Lamp |
F12 (10 a) | Red | Far Light (right headlight) |
F13 (10 a) | Red | Beep, radiator fan (after turning off the engine) |
F14 (10 a) | Red | Reverse Light Lamp, Exterior Mirrors Electric Drive, Washer Nozzle Heating, Seat Heating, Engine Topic Sensor, Automatic Transmission Selector Scale |
F15 (10 a) | Red | Carburetor or electronic system Engine control |
F16 (15 A) | Blue | Combination of devices, discharge box lighting |
F17 (10 a) | Red | Run signs |
F18 (20 a) | Yellow | Electrical displacement, oxygen concentration sensor (lamb-da-probe) |
F19 (30 a) | Green | Cooling system fan, air conditioning |
F20 (20 a) | Yellow | Stop Signals, Motion Speed \u200b\u200bControl System |
F21 (15 A) | Blue | Lamp lighting salon, luggage compartment, clock, central castle, cigarette lighter and instrument combination |
F22 (10 a) | Red | Car radio |
Relay designation
Relay number | Purpose of relay |
Air conditioning system |
|
Rear wiper with intermittent operation function |
|
Switch forced holly-thread, valve increasing speed idle move, ENGLIC SYSTEM SYSTEM (DIGIFANT) |
|
Coolant level pointer |
|
System alarm |
|
Farm cleaning system |
|
Intermittent operation of glass cleaner and washer |
|
Non-unsigned security belts |
|
Fog lights |
|
Sound signal |
|
Fuel pump heated intake manifold (where provided) |
|
Rear window electric heating timer |
|
Hydronasos ABS |
|
Air conditioning system |
|
ABS hydraulic pump fuse and glasses |
|
ABS valve fuse |
|
Access to fuses and relays opens after removing the shelves from the bottom of the front panel. In later models, access opens after the lid removes. The main fuses are located under the relay. The fuses are numbered, and on the shelf or on the lid there is a list of chains that these fuses protect. On some models there are additional fuses and relays that are located above the main.
Cars 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995, 1996, 1997, 1998
Where is the mounting block of the relay and fuses. The block is located at the bottom of the instrument panel from the driver.
Access to the block is possible after unscrewing clamps and removal of tray
The fuse block has a numbering.
On the back side The tray shows the decryption of relays and fuses.
The relays are removed by simple stretching, but are installed by indentation. On some relays placed outside the instrument panel, before removing, it is necessary to remove two plastic brackets. The fuse block and the relay is removed after compressing the fastener brackets from both sides of the block. Staples can be moved forward and remove the relay from the block contacts. Remove the fuse block and relay, removing the lever from the holders to weaken group contacts in the holder holes.
To disconnect the wiring harness of the contact connector from the back of the fuse block and the relay, remove the locks by approximately 5 mm in the direction indicated by the arrow
or click the pinning protrusion of the multiple connector
When installing, make sure that the device locks are clearly fixed.
Mounting Block Relay and Passat B3-B4 Fuses Located in the Salon
Designation of fuses
Fuse number | Fuse color | Protected chain |
Middle Light (left headlight) |
||
Middle Light (right headlight) |
||
Lighting the combination of devices and license plate |
||
Rear door glass cleaner, hatch, self-leveling rear suspension control unit |
||
Windshield Purifier, Wind and Rear Washer |
||
Heater Fan, Air Conditioning |
||
Overall light (right) |
||
Overall light (left) |
||
Rear window heating and rearview mirrors |
||
Fog lights and rear fog lamp |
||
Far Light (left headlight), Far Light Inspection Lamp |
||
Far Light (right headlight) |
||
Beep, radiator fan (after turning off the engine) |
||
Reverse Light Lamps, Outer Mirrors, Washer Nozzle Heating, Seat Heating, Engine Temperature Sensor, Automatic Transmission Selector Scale |
||
Carburetor or Electronic Engine Control System |
||
Combination of devices, discharge box lighting |
||
Run signs |
||
Electrical displacement, oxygen concentration sensor (lambda probe) |
||
Cooling system fan, air conditioning |
||
Stop Signals, Motion Speed \u200b\u200bControl System |
||
Lamp lighting salon, luggage compartment, clock, central locking, cigarette lighter and instrument combination |
||
Car radio |
Relay designation
Relay number | Purpose of relay |
Air conditioning system |
|
Rear wiper with intermittent operation function |
|
Forced Option Switch, idle rotational speed valve, Engine control system (Digifant) |
|
Coolant level pointer |
|
Alarm system |
|
Farm cleaning system |
|
The intermittent operation system of the wiper and washer |
|
Non-unsigned security belts |
|
Fog lights |
|
Sound signal |
|
Fuel pump, heated intake manifold (where it is provided) |
|
Rear window electric heating timer |
|
Hydronasos ABS |
|
Air conditioning system |
|
ABS hydraulic pump fuse and glasses |
|
ABS valve fuse |
|
avtoblokrele.ru.
Volkswagen Passat by DOCENT86 ©\u003e Logbook\u003e Full pinout block of relays and fuses for Volkswagen cars: Golf and Jetta (89-99 G.V.), Passat (90-97 G.V.), All Cabrio, Corrado and Eurovan. As well as all info for fuses and relays.
Record to facilitate the search, and there is no such thing here on the drive ... The location of the fuses and the relay in the BRP VW Passat B3
Location of fuses
01 - 10A - Middle Light Left Headlights02 - 10A - Middle Light of the right lights03 - 10a - Lighting Lighting Panels of instruments and license plate04 - 15A - Rear window wiper, Luke05 - 15A - Wiper and windshield washer, rear window washer06 - 20A - fan stove , air conditioning07 - 10a - right parking lights and rear lights08 - 10a - left oven lights and rear lights09 - 20a - rear window heating and rear-view mirrors10 - 15a - fog lights and rear fog lights11 - 10a - Far light left headlights12 - 10A - Far Light right lights13 - 10A - Bibikalka, The radiator fan after turning off the engine (afterrun) 14 - 10A - reverse light bulbs, outer mirrors with electric drive, heating washer nozzles, heated seats15 - 10A -EPU engine, fuel cut-off valve, speedometer drive sensor16 - 15a - dashboard, glove box, Ashtrays, MFA17 - 10A lamps - turn signs and accidents18 - 20A - fuel pump and heating lambda probe19 - 20A - radiator fan and air conditioner 20 - 10A - Stop signals, cruise21 - 15A - Salon lighting, electronic clock, MFA, trunk highlight, Vacuum CZ
22 - 10a - Magnittol, Cigarette Lighter
Number in BRP - room on the housing - Purpose
01 - 13 - Relay of the air conditioner compressor02 - 72 - rear winner and washer relays03 - 30, 32 - injection and ignition system04 - 18 - Relay Removing the load contact of the ignition switch05 - not used06 - 21 and 22 - RELATIVE INSTRUMENTS OF RADIOT AND ACCURANCES , as well as trailer (№22) 07 - 33 - Relays of the electric motor flew plans08 - 19 and 99 - Relays of janitor and windshield washer09 - 4 and 29 - alarm relay unclosed belts Safety10 - 15 - Wire jumper DYAL PTF11 - 53 - Relay sound signal (For a monochrome signal - jumper) 12 - 67, 80, 167 - relays fuel pump Or Prepass Heater (Diesel) 13 - 53 - Relay preheating (22) or Relay Locking Starter14 - 79 - Relay ABS15 - 79 - Relay ABS16 Hydraulic Pump - 79 - Relay ABS17 - ABS18 Valve Fuses - Seat and Air Conditioning Pump Fuses - Not Used20 - Starter Relay and Reversing Relay21 - Relay Spiral Heating Lambda Pronde22 - not used23 - not used
24 - not used
Rooms on the relay and their appointment number 4 - the signaling relay not fastened seat belts No. 13 - air conditioning compressor №15 - additional headlights (PTF) №18 - tire unloading x №19 or №99 - windshield janitors (№99 - with adjustable pause) №21 - emergency alarm and turn signs №22 - emergency signaling and turn signs, car with trailer №29-root Not fastened seat belts №30 - Raine injection relay, gives a team on the inclusion of fuel pump №32 - Power ECU (Digifant) №33 - headlight washer number 36 -? No. 43 - Indicator of the drop of the coolant level (up to 91G.V.) No. 46 - time relay Pre-starting heating No. 53 - a signal of two tonal (one tonal - jumper) No. 54 - the termination of the feed on the contract. idling number 55 is an increase in the supply of fuel to the submode. idling number 59 - heated seats №61 - heating intake manifold №67 or №80 - gas station №72 - Rear janitor №78 - Pump ABS №61 - ABS ECU No. 80 or No. 67 - Basonasos №99 or №19 - Lob's wipers Glasses (№99 - with adjustable pause) №105 - Climate relay №109 - Injection and ignition system relay (VR6)
№150 - starter and lanterns of the reverse (for cars with automatic transmission)
Full pinout of the bloc of relays and fuses for volkswagen cars: Golf and Jetta (89-99 G.V.), Passat (90-97 G.V.), all Cabrio, Corrado and Eurovan.
Original topic here
Pickup relay
Pickup Slap Dashboard VW Passat B3
PIN in the dashboard connector - PIN in the BRP connector - the color of the wire - signal
T28 / 1- U1 / 7 - BLU / WHT - ambient temperature sensor, massT28 / 2- U2 / 5 - Red / WHT - Sensor low level oh LiquidsT28 / 3 - U1 / 10 - BRN - Terminal 31, MassAt28 / 4 - U2 / 14 - GRY - MFA 4 contact switch, Reset T28 / 5 - U2 / 13 - BRN / WHT - Terminal 31B, MassAt28 / 6 - U2 / 8 - GRN / WHT - MFA switch, MemoryT28 / 7 - U2 / 2 - VIO - Speed \u200b\u200bSensor Output T28 / 8 - U1 / 3 - YEL - Oil pressure, 0.9 / 1.4 / 1.8 BART28 / 9 - U1 / 5 - RED / WHT - Oil pressure, 0.3 BART28 / 10 - U1 / 6 - BLK / GRN - Input signal from the ECU for TachometerT28 / 11 - U2 / 11 - Red - + 12V Permanent, Terminal 30T28 / 12 - U1 / 14 - GRY - backlight panel , Terminal 58BT28 / 13 - U2 / 1 - BLK - + 12V ignition, terminal 15T28 / 14 - according to various sources: add. X1 White Connector - Red / Blk - Extended Signal brake shoes /Counter. Fog Headlight Lamp / Not Used28 / 15 - U2 / 4 - Blk - MFA Switch, 2 Contact, Mode T28 / 16 - U2 / 12 - Blu - Generator Excitation, Terminal 61T28 / 17 - U1 / 1 - BLK / WHT Sensor for oil temperature / 18 - U2 / 10 - BRN - Sensor manual brakes and the level of brake fluidT28 / 19 - U1 / 2 - VIO - the ambient air temperature sensor, the signal (+) T28 / 20 --- - heated candles (diesel) T28 / 21 - U1 / 12 - Blu - Fuel Level SensorT28 / 22 - Extra. X2 2 - BLK / WHT connector - Left28 / 23 - U2 / 9 - YEL / RED rotation indicator - Cooling fluid temperature sensorT28 / 24 - add. X2 Chern 1 - BLK / GRN Connector - Right Point Pointer 28/25 - U2 / 7 - Blu / WHT - Far Light Control Lamp T28 / 26 - Extras. Chern Chern connector - VIO - Fuel consumption signal for cars with Digifant ECU with 01 / 1993T28 / 27 - U1 / 11 - WHT - Input signal for speedometer
T28 / 28 - Add. X1 Sin connector - Red - automatic transmission
Colors Used: Blk - BlackBlu - BlueBln - BrownGrn - GreenGry - GrayRed - RedVio - Purple (Lilac)
WHT - White
Passatovka tapelovka instrumentariginal here, there is still a lot of interesting things about the tidy and their daily diagnosis in the form of blink codes
I. Panels up to 90 years, without turn signals, with one diode - the turning pointer below
1 * - Earth (-) for the outdoor temperature sensor 2 - not used3 - Earth (-), terminal 314 * - to the reset button of the multifunctional indicator (MFI) 5 * - Earth (-), terminal 316 * - to the multifunctional memory switch (MFI) 7 - speed signal from the Hall8 sensor - from the oil pressure sensor (1.8 bar) 9 - from the oil pressure sensor (0.3 bar) 10 - the input of the signal to the tachometer, terminal 111 - plus (+) connection C with Terminal 3012 - plus (+) Connection for the backlight of the instruments, terminal 58b13 - plus (+) connection to the terminal 1514 - not used15 * - to the switch of modes of the multifunction indicator (MFI) 16 - signal lamp Generator (Charging), terminal 6117 * - from the oil temperature sensor18 - Safety belt signal lamp19 * - signal from the outer air temperature sensor 20 - not used21 - to the fuel level pointer22 - signal lamp onboard diagnostics (OBD), 23 - to the coolant temperature pointer24 - to the turn signal indicator25 - to the Far Light Indicator26 - not used27 - not connected28 - not connected
* Cars with a multifunctional indicator (MFI) only for Canada
II. Panels after 90, with separate arrows - turn signs
1 - Earth (-) for the outer air temperature sensor (MFA) 2 - for the engine coolant level sensor (ECL) 3 - ground (-), terminal 314 - to the reset button of the multifunctional indicator (MFA) 5 - Earth (-), Terminal 316 - to the multifunctional indicator memory switch (MFA) 7 - signal from car speed sensor (VSS) with a mechanical speedometer / odometer, signal output from car speed sensor (VSS), speedometer (G22), electronic speedometer (G 21) ), with electronic speedometer / odometerrom8 - from oil pressure sensor (1.8 or 1.4 bar) 9 - from oil pressure sensor (0.3 bar) 10 - signal input to tachometer, terminal 1 (terminal W) 11 - plus (+) connection with With terminal 3012 - plus (+) Connection for highlighting devices, terminal 58b13 - plus (+) Connection with terminal 1514 - not used15 - to the MFA16 mode switch - generator signal lamp (charging), terminal 6117 - from oil temperature sensor (MFA) 18 - Safety Lamp Safety Lamp19 - The signal from the outdoor temperature sensor (MFA) 20 - not used21 - to the fuel level pointer22 - to the indicator of turn signals, left23 - from the coolant temperature sensor (ECT) (for the indicator of the arrow meter) 24 - to the indicator Turning, right25 - to the Far Light Indicator26 - not used27 Speed \u200b\u200bSpeed \u200b\u200bfrom Car Speed \u200b\u200bSensor (VSS), Speedometer (G 22), Electronic Speedometer / Odometer
28 - displaying the position of the gearbox switching lever (for cars with automatic box transmissions)
www.drive2.ru.
Fuses and Relay VW Passat B3 - Logbook Volkswagen Passat 1992 on Drive2
Hello everyone! Here I found info about fuses and relays! On cars Volkswagen Passat B3, all wiring is protected by fuses and relays. There are fuses and relays in the relay and fuse box (photo), down to the left of the steering column, under a small glove box. To open a latch, you need to turn it 90 degrees and pull it on yourself.
№1 - 10 A, Lion. near. Light .№2 - 10 A, right. near. Light.№3 - 10 A, the backlight of the instruments and the number .№4 - 15 A, the rear wiper, hatch, the rear suspension EBU.№5 - 15 A, wiper, windshield washer. No. 6 - 20 A, fan stove, air conditioning .№7- 10 A, right-wing gabritis .№8 - 10 A, left gabritis .№9 - 20 A, heating of the rear window and mirrors. Number 10 - 10 A, additional headlights (PTF) .№11 - 10 A, left Far Light, Control Lamp. No. 12-10 A, Right Far Light .№13 - 10 A, Signal .№14 - 10 A, rear light, electroserkal, heating of the washer nozzles, heating of the seats, the backlight of the ACPP lever .№15 - 10 A, ECU engine .№16 - 15 A, control lamps, MFA, the backlight of the non-awarebox, block for cassettes, ashtrays.№17 - 10 A, signposts of turns. №18 - 20 A, fuel pump, lambda probe. №19 - 30 A, radiator fan, air conditioning. # 20 - 10 A, Stop signals, cruise control .№21 - 15 A, interior lighting, trunk, cigarette lighter, clock, MFA, CZ.22 - 10 A, radio.
Room rooms:
№67 or №80 - gas station.
№220 - Relay After-Run.№13 - electromagnetic coupling Drive valves airproke .№79 - Ab abs.№78 - ABS pump.
№59 - heated seats.
If there are any additions or clarifications, write "in the comments".
www.drive2.ru.
Fuses, relays and email. Schemes Volkswagen Passat B3 - Logbook Volkswagen Passat Variant Syncro (2e) Arriva 1993 on DRIVE2
Fuses, (from left to right):
№1 - 10 A, Lion. near. Light .№2 - 10 A, right. near. Light.№3 - 10 A, the backlight of the instruments and the number .№4 - 15 A, the rear wiper, hatch, the rear suspension EBU.№5 - 15 A, wiper, windshield washer. No. 6 - 20 A, fan stove, air conditioning .№7- 10 A, right-wing gabritis .№8 - 10 A, left gabritis .№9 - 20 A, heating of the rear window and mirrors. Number 10 - 10 A, additional headlights (PTF) .№11 - 10 A, left Far Light, Control Lamp. №12-10 A, Right Far Light .№13 - 10 A, Signal .№14 - 10 A, Rear Light, Electrozerkala, Heating Washer Nozzles, Heated Seats, Lighting of the ACPP lever. №15 - 10 A, ECU engine .№16 - 15 A, test lamps, MFA, Blur drawer illumination, block for cassettes, ashtrays. №17 - 10 A, signposts of turns. №18 - 20 A, gas station, lambda probe. №19 - 30 A, radiator fan, air conditioning. №20 - 10 A, stop signals, cruise control .№21 - 15 A, lighting of the cabin, trunk, cigarette lighter, clock, MFA, CH.
№22 - 10 A, radio.
Room rooms:
№13 - air conditioner compressor .№72 - Rear janitor .№32 - ECU meals (Digiphant) .№54 - stopping for a contract. idling .№55 - an increase in fuel supply to the force. idling .№18 - tire unloading .№43 - indicator of the drop of the coolant level (up to 91g.). No. 21 - alarm and turn signs. No. 2 - alarm alarm and turn signs, a car with a trailer. No. 33 - Player Far .№19 or №99 - Wipers of the windshield (№99 - with an adjustable pause) .№4 - alarm relay not fastened safety belts. No. 15 - Additional headlights (PTF) .№53 - two tonal signal (one tonal - Jumper) .№61 - Heated intake manifold .№46 - Time relay Preheating heating.
№67 or №80 - gas station.
Additionally, it can be installed:
№87 Relay of inclusion Sync№220 - Relay After-Run.№13 - Electromagnetic Coupling Drive Drive Air Purpose .№79 - ECU ABS. Number 78 - ABS pump.
№59 - heated seats.
The location of the relay on the Folkswagen Passat B3 fuse block, depending on the engine model and car configuration, from above, from left to right:
01 - №13 - Relay of the air conditioner compressor.02 - №72 - Relay of the rear janitor and washer.03 - №32 - Injection and ignition relay.04 - №18 - Relay Removing the load of contact x (tire unloading) .05 - not used .06 - №21 or №22 - Relay-interrupters of indicators of rotation and alarm, as well as trailer (№22) .07 - №33 - Electrical motors of the plans washer - №19 or №99 - the relay of janitor and windshield washer .09 - №4 or №29 - Signaling relay "not fastened" safety belts.10 - №15 or No. 53 or jumper for PTF.11 - No. 53 - sound signal relay (for one tone signal - jumper).
12 - №67, №80, (№167) - The relay of the fuel pump, (pre-trigger heater - diesel).
The number of relays, in the relay and fuse block, may differ depending on the configuration.
